Introduction

The standard model Lotus Evora comes with the choice of 3 gearboxes, the standard 6-speed manual, the Close Ratio Gearbox - again a 6-speed manual but with a closer ratio gear set - and the Lotus IPS 6-speed automatic (this makes the car an Evora IPS).

All three of these gearboxes are Toyota sourced, with the IPS featuring Lotus's own electronic controls to make it more suitable for a sporting application.

Manual gearbox information

For the manual gearboxes this is the Toyota EA60 gearbox, as fitted to the Toyota Auris 2.0 D-4D and 2.2 D-CAT models.¹ These are diesel engines, and the standard ratios are as they in the Auris, possibly explaining why they are often seen as rather long. The closer ratio gear set appears to be a bespoke set of ratios unique to the Evora and Evora S.

An adaptor plate is used to allow the engine and gearbox to be joined together, and the starter motor is relocated compared to the Toyota application.

For the manual gearboxes Lotus list two final drive ratios, one for 1st through 4th gears and another slightly shorter ratio for 5th and 6th.²

Automatic gearbox information

The Evora IPS most likely uses the Toyota U660E gearbox³ as this is used by Toyota in conjunction with the 2GR-FE engine in several vehicles and is a match for Lotus's quoted gear ratios.

There are 3 modes of operation for the IPS gearbox: Drive, Sport, and paddle over-ride.⁴

Drive

Drive is biassed towards fuel economy, generally keeping the engine below 2000rpm.

Sport

Sport mode adds throttle blips on downshifts and generally runs the engine at higher revs to improve responsiveness.

Paddle

Paddle mode is activated by pulling on one of the paddles in either Drive or Sport mode, and allows the driver to change gear with the paddles mounted behind the wheel.
After either 10 seconds (Drive mode) or 30 seconds (Sport mode) without any paddle changes the car will revert back to the previous selected Automatic mode. It is possible that this value may be reprogrammable to suit the owners preference. It is also suggested that in Sport with Paddle mode the gearbox will not automatically shift up when the rev limiter is hit.⁵

Unlike the manuals, cars fitted with the IPS gearbox do not have the engines rev limit increased to 7000rpm when in Sport Mode, as this would damage the gearbox.⁶

Other information

The Evora S is not available with the IPS gearbox, and comes with the close ratio Sport Gearbox fitted as standard.

Gear Ratios

Gearbox	1	2	3	4	5	6	Reverse	Final Drive 1st - 4th	Final Drive 5th - 6th
Standard	3.538	1.913	1.218	0.86	0.79	0.638	3.831	3.777	3.238
Close Ratio	3.538	1.913	1.407	1.091	0.9697	0.8611	3.831	3.777	3.238
IPS	3.300	1.900	1.420	1.000	0.713	0.608	Unknown	3.935⁷	3.935

Maximum Speed per gear

Speeds displayed at 6400rpm and 7000rpm in brackets for Sport Mode.

Gearbox	1	2	3	4	5	6
Standard	37.09mph (40.57mph)	68.60mph (75.03mph)	107.75mph (117.85mph)	152.60mph (166.90mph)	193.77mph (211.94mph)	239.94mph (262.43mph)
Close Ratio	37.09mph (40.57mph)	68.60mph (75.03mph)	93.27mph (102.02mph)	120.29mph (131.56mph)	157.86mph (172.66mph)	177.77mph (194.44mph)
IPS	38.17mph	66.30mph	88.71mph	125.96mph	176.71mph	207.18mph

Emissions

The official CO₂ emission and fuel consumption ratings for the Evora vary depending on the gearbox equipped to the car.

	Evora	Evora Sport Gearbox	Evora IPS	Evora S
Fuel Consumption - Urban	23.4mpg (12.1 l/100km)	22.1mpg (12.8 l/100km)	22.4mpg (12.6 l/100km)	19.4mpg (14.6 l/100km)
Fuel Consumption - Extra Urban	44.8mpg (6.3 l/100km)	40.4mpg (7.0 l/100km)	44.8mpg (6.3 l/100km)	37.2mpg (7.6 l/100km)
Fuel Consumption - Combined	33.2 (8.5 l/100km)	31.0mpg (9.1 l/100km)	33.2mpg (8.5 l/100km)	27.2mpg (10.2 l/100km)
CO₂ Emissions - Urban	285g/km	301g/km	297g/km	341g/km
CO₂ Emissions - Extra Urban	149g/km	165g/km	156g/km	179g/km
CO₂ Emissions - Combined	199g/km	215g/km	208g/km	239g/km